Fluoride Action Network

Simplified Batch and Fixed-Bed Design System for Efficient and Sustainable Fluoride Removal from Water Using Slow Pyrolyzed Okra Stem and Black Gram Straw Biochars

Source: ACS Omega 4(22):19513-19525. | November 11th, 2019 | Authors: Kumar H, Patel M, Mohan D.
Location: International
Industry type: Water Treatment

Abstract

Okra stem biochar (OSBC) and black gram straw biochar (BGSBC) were prepared by slow pyrolysis at 500 and 600 °C, respectively. OSBC and BGSBC were characterized using SBET, Fourier transform infrared, X-ray diffraction, scanning electron microscopy (SEM), transmission electron microscopy, SEM–energy dispersive X-ray, and energy dispersive X-ray fluorescence. High carbon contents (dry basis) of 66.2 and 67.3% were recorded in OSBC and BGSBC, respectively. The OSBC surface area (23.52 m2/g) was higher than BGSBC (9.27 m2/g). The developed biochars successfully remediate fluoride contaminated water. Fluoride sorption experiments were accomplished at 25, 35, and 45 °C. Biochar-fluoride adsorption equilibrium data were fitted to Langmuir, Freundlich, Sips, Temkin, Koble–Corrigan, Radke and Prausnitz, Redlich–Peterson, and Toth isotherm models. The sorption dynamic data was better fitted to the pseudo-second order rate equation versus the pseudo-first order rate equation. The Langmuir sorption capacities of QOSBC0 = 20 mg/g and QBGSBC0 = 16 mg/g were obtained. Biochar fixed-bed dynamic studies were accomplished to ascertain the design parameters for developing an efficient and sustainable fluoride water treatment system. A column capacity of 6.0 mg/g for OSBC was achieved. OSBC and BGSBC satisfactorily remediated fluoride from contaminated ground water and may be considered as a sustainable solution for drinking water purification.

*Read the full article online at https://pubs.acs.org/doi/10.1021/acsomega.9b00877

Figure 1. Experimental set-up for biochar preparation and fluoride sorption.